Concrete Services · Duluth, MN
A concrete driveway is the single most visible piece of hardscape on your property — and in a Duluth winter, it has to fight freeze/thaw cycles, road salt, and plow trucks. We pour driveways that last. Proper sub-base preparation, reinforcement, a true 4,000 PSI mix, and control joints cut where they belong. That's the difference between a driveway that looks good for twenty years and one that cracks in three.
What you get
We pour to spec. Standard residential driveways get 4 inches of 4,000 PSI concrete over 6 inches of compacted Class-5 base. RV pads, commercial approaches, and driveways that see dually trucks get 5–6 inches reinforced with #4 rebar on 18-inch centers.
We walk you through the trade-off. Rebar adds tensile strength for heavy loads. Fiber mesh controls micro-cracking and is enough for most residential driveways. No upsell, just what your driveway actually needs.
Concrete will crack. The question is where. We saw-cut control joints at the right depth and spacing (typically 10 feet for a 4-inch slab) so the slab cracks at the joint, not across the field. Isolation joints go against the garage apron and any fixed structure.
A flat driveway is a failed driveway. We set forms with a minimum 1/4-inch per foot slope away from the house and any structures, and work with you on pitch points if your lot drains oddly.
Seen on the ground
Every concrete driveways job we take in Duluth and the Twin Ports gets the same treatment: a careful site walk, a written estimate, proper prep, and work that holds up through Minnesota winters.
If you’re not sure whether we’re the right fit, call — we’ll tell you honestly. If it’s outside our wheelhouse or service area, we’ll point you to somebody who can help.
Our process
We walk the site, check existing grade, ask about your use case (everyday car, RV, plow turnaround), and give you a written quote.
If we're replacing an old driveway, we break it out, haul it off, and excavate to subgrade. Any soft spots get dug out and replaced with compacted fill.
6 inches of Class-5 compacted in lifts, forms set to grade, rebar or fiber per the spec we agreed on.
4,000 PSI mix, broomed finish for traction, control joints cut the day of the pour. Cured with a sealer or wet cure depending on weather.
We cover
Concrete Driveways work by Hercules Jr. Excavating and Concrete is available throughout Duluth, Superior (WI), Two Harbors, Esko, Proctor, Hermantown, Cloquet, and surrounding communities. If your project is in northeastern Minnesota or northwestern Wisconsin, there's a strong chance we can serve you — call to confirm.
Call or text (218) 464-8641 — Tim answers. Or email Herculesexcavating@gmail.com.
Questions?
Free estimates. No pressure. Call Tim directly or use the contact form — whichever works for you.
